What is an eye haircut?

Eye haircut is a common method to create a permanent loop at the end of the stuck rope while maintaining at least 85 percent of the rope strength. Eye haircut is made by tissues or tuckery the end of the individual springs of the rope into the rope itself. Eye haircut was originally made of three complete tucks when the snowy was made of cotton or cannabis. Since technology is advanced and more synthetic ropes are used, it is now recommended to use at least five or more for security. The eye joint is commonly used with wire ropes.

In order to determine how long you unpack the rope spring, the rope diameter should be taken and multiplied by three, then the number of tucking. For example, a 1 -inch rope (2.54 cm) with five insertions would unpack 15 inches (38.1 cm). The rope base should be glued to prevent further disintegration and provide a reference point for the loop. After the length and rope is indicated, the ends are melted to prevent distribution. Every end of the rope should be packedtape to form a tip to help connect the ends into a firmly woven or new rope.

As with any weaving, the remaining strands are likely to turn. They could even get entangled. With each link, one should straighten the remaining strands and unravel them if necessary to move to further tuck.

If you want to start the eye connection, you should take unpacked strands and lay them over the rope base to create a loop. One should notice which spring is inside the rope base, center and outside. Weaving the central strand to the rope base can begin by going under the rope spring.

The inner spring can be taken and tucked into the next spring at the base of the rope. The middle spring goes to the place where the first spring came out. One should then turn the rope and remove the Seide Strand that has not yet been used. Strand should be tucked where the middle spring came out and firstMen entered in, which completes one tuck. One should then weave and tuck until at least five fats are completed.

After completing the number of required fats, a small amount of rope could remain. It is best for one to take the next time to cut again and melt the end. If the eye clutch loop repeatedly stresses or piled due to the friction of another rope, the loop should be packed with a tear -resistant strip or thimble for ropes to prevent damage.

IN OTHER LANGUAGES

Was this article helpful? Thanks for the feedback Thanks for the feedback

How can we help? How can we help?